济南科邦机械设备有限公司您身边的济南空压机厂家!
17553037111   18765879198

首页>企业新闻
无油空压机主机周期性为什么会出现大修?
Time:2019-03-01 14:15:32       来源:http://www.jnkbjx.com/      

(1)磨损增大

(1) Increased wear
众所周知,只要是机械在工作都存在磨损,正常情况下由于有光滑液光滑,磨损会减轻很多,但长时间高速工作,磨损是在慢慢增大的。
As we all know, as long as there is wear in the work of machinery, under normal circumstances, due to smooth liquid, wear will reduce a lot, but long time and high speed work, wear is slowly increasing.
以山东复盛空压机SKF轴承为例:在近乎不可能的条件下(如长时间空转、光滑液足够干净、冷却系统足够好、及运用环境温度、湿度等等),也只能保证数年。就紧缩机主机而言,除轴承外还存在其它部件的磨损。如轻微磨损不采取正确的预防措施,很容易导致磨损增大、造成其它首要部件的损坏和磨损。
Take the SKF bearing of Shandong Fusheng air compressor as an example: under almost impossible conditions (such as long time idling, clean enough smooth liquid, good enough cooling system, and the use of ambient temperature, humidity, etc.), it can only be guaranteed for several years. As far as the compressor main engine is concerned, there are wear and tear of other parts besides bearings. If slight wear does not take the correct preventive measures, it will easily lead to increased wear, causing damage and wear of other primary components.
空压机
Air compressor
(2)部件变形
(2) Component Deformation
空气紧缩机主机是紧缩机的核心紧缩部件,其内部部件长时间处于高温、高压的环境中,再加上高速的工作,时间一长必定存在部件变形的现象。一起,造成变形的原因还有运用环境要素,而空气紧缩机一般运用的环境的空气中都会有尘土和杂质,这些细小的固体物质在进入机器后,日积月累若结成较大的固体块,就有可能造成阴阳转子变形,空隙增大,严重的会导致主机卡死。
济南空压机
The main engine of air compressor is the core part of the compressor. Its internal parts are in high temperature and pressure environment for a long time, coupled with high-speed work, there must be part deformation for a long time. Together, the cause of deformation is also the use of environmental factors, and air compressor generally used in the environment will have dust and impurities, these fine solid substances into the machine, accumulated over time into larger solid blocks, it is possible to cause Yin and Yang rotor deformation, void increase, serious lead to the main engine jam.
(3)本钱添加
(3) Cost addition
这里本钱指保养本钱和电力本钱。由于空气紧缩机主机在长时间工作未大修,部件磨损增大,一些磨损的杂质留在主机腔内,会造成光滑液寿命缩短,
Here cost refers to maintenance cost and power cost. Because the main engine of air compressor has not been overhauled for a long time, the wear of parts increases, and some wear impurities remain in the main engine chamber, which will shorten the life of smooth liquid.
一起,由于杂质的原因,油气分离器芯和油过滤期的运用时间大大缩短,构成保养本钱添加。在电力本钱方面,由于磨擦增大和紧缩效率降低,必定会构成电力本钱增大。由于紧缩机主机的原因构成的气量下降、紧缩空气质量下降也会构成生产本钱的直接增大。
Together, due to impurities, the operation time of oil and gas separator core and oil filtration period is greatly shortened, which constitutes maintenance cost addition. In terms of power cost, because of the increase of friction and the decrease of contraction efficiency, it will certainly constitute an increase in power cost. The decrease of air volume and air quality caused by the main engine of the compressor will also directly increase the production cost.
(4)部件损坏
(4) Component damage
在空压机主机部分的易损部件首要有:各种垫片、密封圈、轴油封等,尤其是轴油封,长时间处于高温、高压、和高速工作的环境中,其运用寿命比大大缩短。其损坏的直接后果是构成紧缩机漏油,如未能及时发现,则会构成阴阳转子和轴承因缺少光滑而焚毁。
The vulnerable parts of the main part of the air compressor mainly include gaskets, sealing rings, shaft oil seals, etc. Especially the shaft oil seals, which have been working at high temperature, high pressure and high speed for a long time, and their service life ratio is greatly shortened. The direct consequence of its damage is that it constitutes oil leakage of the compressor. If it is not found in time, it will constitute Yinyang rotor and bearing which will be burned due to lack of smooth.
本文由济南空压机提供技术支持,更多的详细精彩内容请点击我们的网站http://www.jnkbjx.com,我们将会全心全意为您提供满意的服务。
This article is supported by Jinan Air Compressor. For more details, please click on our official website http://www.jnkbjx.com. We will provide you with satisfactory service wholeheartedly.

电话:0531-85963300      手机:17553037111   18765879198    地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁ICP备18021911号-1

济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com     

鲁公网安备 37010502001004号