济南科邦机械设备有限公司您身边的济南空压机厂家!
18765879198

首页>企业新闻
初春时节我们怎么使用好空压机?
Time:2018-12-10 16:47:56       来源:http://www.jnkbjx.com/      

在空压机不长时刻运用时:空压机系统冷却水走地下应该不至于冻裂,可是初春时节,气温没有安稳,要是突然严寒,同时不是很经常开空压机的话,也应该把水放掉。冬天气温低比体积下降压缩空气耗功略微增加,但冷却水耗功会降低,两者影响此消彼长。给出对空压机很好的日常保护的主张;主要是润滑油的保护,避免堵塞、高温碳化进一步阻塞油路。

When the air compressor is not used for a long time: the cooling water of the air compressor system should not freeze and crack when it goes underground, but in the early spring, the temperature is not stable. If the air compressor is suddenly cold and not very often opened, the water should also be released. The power consumption of compressed air increases slightly with the decrease of low specific volume of air temperature in winter, but the power consumption of cooling water decreases. The idea of good routine protection for air compressor is given, mainly for the protection of lubricating oil to avoid blocking and high temperature carbonization to further block oil pipeline.
此外关于空压机开机:螺杆空压机冬季的启动方式为:先断开冷却电扇开关,按下“Start”按钮,使螺杆空压机空载运转。经过显现器调查螺杆空压机的运转状况,当卸载运转时的螺杆空压机温度到达75—80℃左右时,运用测温枪或用手触摸冷却器进、出口的温度即承认恒温温控阀翻开。
In addition, about the start-up of air compressor: screw air compressor in winter start-up mode is: first disconnect the cooling fan switch, press the "Start" button, so that the screw air compressor idle operation. The operating condition of the screw air compressor is investigated by the display device. When the temperature of the screw air compressor reaches about 75-80 C during unloading operation, the constant temperature control valve is admitted to be opened by using the temperature measuring gun or touching the temperature of the inlet and outlet of the cooler by hand.
济南空压机
如果出口温度没有升高,螺杆空压机可在卸载状态下持续运转到90℃左右,再次对冷却器的进、出油口进行承认,待出口和进口的温差在20~30℃时,使螺杆空压机加载运转。查看螺杆空压机油箱油位,加载运转时,油位保持在油视镜中部位置为好。
If the outlet temperature does not rise, the screw air compressor can continue to operate to about 90 C under the unloading condition. Once again, the inlet and outlet of the cooler are recognized. When the temperature difference between the outlet and the import is 20-30 C, the screw air compressor can be loaded and operated. Check the oil level of the oil tank of the screw air compressor. When loading and running, it is better to keep the oil level in the middle of the oil mirror.
加载运转时,操作人员不得离开螺杆空压机启动柜,应仔细调查螺杆空压机的显现数据,并根据实践显现的结果进行准确的判断,螺杆空压机是否能够持续运转。如果一切数据显现正常,此时应主要调查螺杆空压机排气温度,当温度上升到9O~95℃时,合上电扇操控开关。此时,操作人员应经过操控器查看机组在全负荷状态下的运转状况,机组及冷却器周围是否有漏油现象,待螺杆空压机运转15~25min,如果显现一切正常,标明螺杆空压机进入了正常运转,操作人员方可离开启动柜。
When loading and running, the operator must not leave the screw air compressor starter cabinet, should carefully investigate the screw air compressor display data, and accurately judge whether the screw air compressor can continue to operate according to the results of practice. If all the data are normal, the exhaust temperature of screw air compressor should be mainly investigated at this time. When the temperature rises to 9O-95 C, the fan control switch should be closed. At this time, the operator should check the operation status of the unit under full load through the controller, whether there is oil leakage around the unit and cooler, and wait for the screw air compressor to run for 15-25 minutes. If everything is normal, it indicates that the screw air compressor has entered the normal operation, the operator can leave the startup cabinet.
本文由济南空压机整理发布,您是不是对这些内容有所了解了呢?更多的内容请点击:http://www.jnkbjx.com我们会有更多精彩内容等你查看。
This article is organized and published by Jinan Air Compressor. Do you have any idea about these contents? For more information, please click: http://www.jnkbjx.com. We will have more wonderful contents for you to check. uuuuuuuuuu

电话:0531-85963300     手机:18765879198   地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁公网安备 37010502001004号 >

版权所有:济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com    技术支持:诺商信息

鲁公网安备 37010502001004号