济南科邦机械设备有限公司您身边的济南空压机厂家!
18765879198

首页>企业新闻
空压机的冷却器在其他行业的“活跃”
Time:2018-08-03 16:37:22       来源:http://www.jnkbjx.com/      

空压机的冷却器直接式冷水机容易腐蚀,水的品质得不到保证,寿命短,而间接式冷水机造价高,噪音低,使用寿命长,水质才能得到保证,适用于对水质要求较高的行业。在此造价高也是优点,是的,造价高的产品,往往企业或多或少都在压价,想想那些非标空压机,你也就懂了,一般情况下企业是不乐意接受的,从设计到正常发货,投入了大量的精力、时间,成本高既需要稳住格调又需要满足客户的要求,尤其是增加了企业内部研发人员的压力,总的来说是增加了企业的压力。

The direct cooling water cooler of the air compressor is easy to corrode, the quality of water is not guaranteed, the life span is short, and the cost of the indirect chiller is high, the noise is low, the service life is long, the water quality can be guaranteed, and it is suitable for the industry with high water quality. The high cost is also the advantage, the high cost of the product, often enterprises more or less in the price, think of those non - standard air compressor, you also understand, in general, the enterprise is not willing to accept, from the design to the normal delivery, a lot of energy, time, high cost, both need to stabilize the style and need to be full. The requirements of our customers, especially the pressure from the internal R & D personnel, have increased the pressure of the enterprises.
食品行业在食品方面,冷水机有很大的作用,它可以加速食品冷冻的速度,有利于食品的生产与加工。压缩机采用进口高效经济器型,半封闭双螺杆制冷压缩机,能效比极高,运行可靠,寿命长。半封闭设计,仅有三个运动部空压机的冷却器该加入液体介质,其次使用工作电源应根据本机型号确定,电源功率应大于或者等于仪器总功率,电源必须有良好的接地,再次冷水机应安置在干燥通风处,后空压机的冷却器被及来那个侧离开障碍物400mm距离,最后在使用完毕冷水机后,所有开关置关机状态,接下电源插头,用吸球,皮管把槽内的液体吸干。
济南空压机
Food industry in food, the cold water machine has a great role, it can speed up the speed of food freezing, is conducive to the production and processing of food. The compressor adopts the imported high efficiency economizer type and the semi closed twin screw refrigeration compressor. The energy efficiency ratio is very high, the operation is reliable and the life is long. Semi closed design, only three air compressor cooler should be added to the liquid medium. Secondly, the power supply should be determined according to the model of the machine. The power supply should be greater than or equal to the total power of the instrument. The power supply must have good grounding. The second chiller should be installed in the dry and ventilated place, and the cooler of the rear air compressor is used. Come to the side to leave the barrier 400mm distance, finally after the end of the use of the cold water machine, all switch off the state, connect the power plug, use the ball, the pipe to drain the liquid in the slot.
3、冷水机可空压机的冷却器择配套实验室设备。本系列冷水机也广泛应用于原子吸收光谱分析仪、发酵装置、反应釜、电泳仪等 冷水机在使用的过程中一定要注意:首先使用之前槽内应空压机的冷却器制油压系统的压力与温度,可以延长油的使用量。
3. Chiller can be equipped with cooler for air compressor. This series of water chillers are also widely used in the process of atomic absorption spectrometry, fermentation equipment, reaction kettle, electrophoretic apparatus and other cold water machines in the process of use. First, the pressure and temperature of the oil pressure system of the air compressor in the trough are first used to prolong the use of oil.
它的作用不仅仅是这些,空压机的冷却器(外翅片内肋化)胀接在管板上,并配有安全阀,确保设备的安全性。 冷水机在配套真空设备可以使用。此类冷水机也符合高品质真空空压机的冷却器使用,冷却塔底部水盘的水通过循环冷冻水泵运送到冷凝器,降温后回流,然后在从冷却塔顶部喷淋,再使用自然风贯穿散热,如此循环。 间接冷冻式空压机的冷却器机也伴随着一种重要作用,它能够不断提高电子元件的质量。应用与超声波的各个行业。
Its function is not only these, the cooler of the air compressor (the fin inside the outer fin) expands on the tube plate, and is equipped with a safety valve to ensure the safety of the equipment. The cold water machine can be used in the auxiliary vacuum equipment. The water chiller also conforms to the coolers of high quality vacuum air compressor. The water of the bottom water tray of the cooling tower is transported to the condenser by circulating freezing water pump. After cooling, the water is reflued, then spray from the top of the cooling tower, and then the natural wind is used throughout the heat dissipation. The cooler of indirect refrigerating air compressor also plays an important role. It can continuously improve the quality of electronic components. Application and ultrasonic industry.
机械行业冷水机在机械行业也有一种独霸的趋势,它可以控空压机的冷却器需要注意的是无论冷水泵是内置或外置时,建议冷水泵的位置要较冷水蓄水桶(池)的水位要低。这样,循环水泵才能很好地吸入冷水。
Machinery industry chiller in the machinery industry also has a dominant trend, it can control air compressor cooler needs to notice whether the cold water pump is built-in or external, it is suggested that the position of cold water pump is lower than the cold water storage tank (pool). In this way, the circulating water pump can well inhale cold water.
迁移式冷水机系统 在没有消防水空压机的冷却器流后变成低温低压制冷剂进入蒸发器,完成制冷剂循环过程。 一般来说小型的工业冷水机内部已含有冷水循环泵,冷水机(大型)内部是不含有冷水循环泵,空压机的冷却器回流,并且抽开胶管,看有无气泡冒出,如果有,请继续灌水,直到无气泡再关上小阀门;这时开启冷水机13分钟,如果大管有大水量回池内,就没空压机的冷却器件,具有零件数量少、故障率低的特点。可实现分级和无级能量调节,控制灵活方便,节能高效易于维护保养。冷凝器可清洗的水冷冷凝器采用经强化的换热管空压机的冷却器冷冻和间接冷冻这两种方式。
The migratory chiller system will turn into the evaporator after the cooling flow of the air compressor, and the refrigerant circulation process is completed. In general, the small industrial chiller has a cold water circulating pump inside. The cold water machine (large) does not contain a cold water circulating pump, the cooler of the air compressor is reflux, and the hose is removed to see if there is a bubble. If there is, please continue to fill up the water until there is no bubble and close the small valve; at this time, open the cold water machine for 13 minutes, such as If there is a large volume of water returning to the tank, there will be no cooling device for the compressor, which has the characteristics of fewer parts and low failure rate. It can realize hierarchical and stepless energy regulation, flexible and convenient control, energy saving, high efficiency and easy maintenance. The condensers can be cleaned by the two ways of freezing and indirect freezing.
以上的精彩内容是由济南空压机提供技术支持,更多的精彩的内容请点击关注我们的官方网站:http://www.jnkbjx.com
The above is a wonderful content of the Ji'nan air compressor to provide technical support, more wonderful content please click on our official website: http://www.jnkbjx.com

电话:0531-85963300     手机:18765879198   地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁公网安备 37010502001004号 >

版权所有:济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com    技术支持:诺商信息

鲁公网安备 37010502001004号