济南科邦机械设备有限公司您身边的济南空压机厂家!
18765879198

首页>企业新闻
无油空压机适应现代化工业的条件
Time:2018-07-19 17:57:07       来源:http://www.jnkbjx.com/      

1)、压力、流量的要求:任何需要压缩空气的场合对压缩空气的压力和流量都是有要求的。目前最普遍的压力值在0.7MPa(g)左右。在一些特殊场合如玻璃行业,对压缩空气的压力要求可能为0.2-0.4 MPa(g)左右;在某些军工企业,对压缩空气压力要求可能在几十MPa。市场上有各种各样的空压机可以来满足这些要求。

1), pressure and flow requirements: any occasion requiring compressed air is required for compressed air pressure and flow. At present, the most common pressure value is about 0.7MPa (g). In some special occasions, such as the glass industry, the pressure on compressed air may be about 0.2-0.4 MPa (g); in some military enterprises, the pressure of compressed air pressure may be at dozens of MPa. There are all kinds of air compressors in the market to meet these requirements.
2)、干燥度(即含水量或露点温度)的要求:不同的工艺对压缩空气露点温度要求也不同,如用作仪表方面的压缩空气压力露点一般要求在-40℃以下,而在半导体芯片厂对压缩空气的压力露点可能要求在-70℃,但在多数场合,对压缩空气的露点温度要求在0℃左右就已足够。压缩空气的露点要求通常由压缩空气干燥机来实现。
2), drying degree (water content or dew point temperature) requirements: different processes for compressed air dew point temperature requirements are also different, such as the compressed air pressure dew point for the instrument is generally below -40 C, and the pressure dew point for compressed air in the semiconductor chip plant may be required at -70 C, but on most occasions, The dew point temperature requirement of compressed air is enough at 0 degrees Celsius. The dew point requirements of compressed air are usually achieved by compressed air dryers.
3)、寿命上
3), life span
济南空压机
1、普通无油机在不带压情况下连续工作时间500小时,我们的无油机在带压情况下可以连续工作12000小时;如果间歇性使用的话我们的无油机的寿命是在30000小时以上,普通的为5000小时以内;
1. The ordinary oil free machine works continuously for 500 hours without pressure. Our oil free machine can work continuously for 12000 hours under pressure condition. If intermittent use is used, the life of our oil free machine is over 30000 hours and ordinary for 5000 hours.
2、普通无油机的活塞与缸套接触面为1%,容易高温;我们的无油机活塞与缸套接触面为100%,所以不会产生高温,并且我们的活塞材质采用德国PEEP高耐磨密封材料。
2, ordinary oil free piston and cylinder contact surface is 1%, easy to high temperature; our oil free piston and cylinder contact surface is 100%, so it will not produce high temperature, and our piston material is the German PEEP high wear resistant seal material.
3轴承方面普通无油机都是使用国产轴承,我们的无油机采用原装进口SKF轴承,这样保证了工作的稳定性;
3 bearings, ordinary oil-free machines are made of domestic bearings. Our oilless machine imported SKF bearings in original form, so as to ensure the stability of the work.
4)、使用环境方面普通无油机防护等级是IP54,我们的无油机防护等级最低是IP55,最高是IP67,放在水里也能正常工作,所以能满足各种环境的使用。
4), the use of the environment of ordinary oil free machine protection level is IP54, our oil free machine protection level is the lowest IP55, the highest is IP67, in the water can also work normally, so can meet the use of all kinds of environment.
5)、保养成本方面在环境恶劣条件下,我们的机器每半年换一次空滤,2支空滤成本在10元左右,所以一年保养成本在20左右;普通无油机在环境恶劣条件下每三个月要更换缸套,密封圈,空滤,活塞环,成本在500元左右,所以我们无油机的保养成本、维护费用低。
5), the maintenance cost in bad environment conditions, our machine every half a year to change the air filter, 2 air filter costs about 10 yuan, so one year maintenance cost about 20; ordinary oil free machine in bad conditions every three months to replace cylinder liner, seal ring, air filter, piston ring, the cost of about 500 yuan, so The maintenance cost and maintenance cost of our oilless machine are low.
以上的精彩内容由济南空压机进行推荐阅读,想要知道更多有用的知识,欢迎点击:http://www.jnkbjx.com。
The above highlights are recommended by Ji'nan air compressor, and you want to know more useful knowledge. Welcome to click: http://www.jnkbjx.com.

电话:0531-85963300     手机:18765879198   地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁公网安备 37010502001004号 >

版权所有:济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com    技术支持:诺商信息

鲁公网安备 37010502001004号