济南科邦机械设备有限公司您身边的济南空压机厂家!
17553037111   18765879198

首页>企业新闻
济南空压机的日常的使用特点及注意事项
Time:2018-05-30 14:25:27       来源:http://www.jnkbjx.com/      

一、j济南空压机的运行环境中如果带有腐蚀性或刺激性的气体,如硫化物、清洗用的化学制剂等发在空气中。压缩机本身的高温就加速了机油的氧化,一旦这些气体进入空压机系统内,就会与润滑油发生化学反应,从而产生积碳和油泥等。一部分杂质进入润滑油循环系统会被油过滤器拦截,而另一部分的杂质会随着油气混合物上升到油分,在气体通过油分时,这些杂质滞留在油分滤纸上,将过滤孔堵塞,油分的阻力就会慢慢增大,致使油分在较短的时间内就需要提前更换。
1. If the air compressor operates in a corrosive or irritating gas, such as sulphides and chemicals used in cleaning, it will be in the air. The high temperature of the compressor itself accelerates the oxidation of the oil. Once the gas enters the air compressor system, it will react with the lubricating oil to produce carbon and sludge. Some impurities entering the lubricating oil cycle system will be intercepted by the oil filter, and the other part of the impurities will rise to the oil and gas mixture with the oil and gas mixture. When the gas passes the oil, the impurities are stuck on the oil filter paper, the filter holes are blocked and the oil separation resistance will gradually increase, resulting in the oil in a short time. Change in advance.
二、一般情况下,温度越高,空压机的排气温度就越高,而且排气温度就越难控制。如果工作的环境温度高,那么其空气的压强也就越小,很难发挥出空压机的应有作用。
Two, under normal circumstances, the higher the temperature, the higher the exhaust temperature of the air compressor, and the more difficult it is to control the exhaust temperature. If the temperature of the working environment is high, the pressure of the air will be smaller. It is very difficult to play the proper role of the air compressor.
三、过滤精度差的空气过滤器会让部分空气中的粉尘颗粒无法被拦截,而直接进入空压机系统,使油滤和油分的负荷过大,导致油滤和油分过早出现堵塞。
Three, the filter precision of the air filter can not be intercepted in some air dust particles, and directly into the air compressor system, so that the oil filter and oil load is too large, leading to oil filtration and oil separation too early.
四、油分滤材上的水份过多会使滤材发胀、微孔收缩,使油分的有效分离面积减少,导致油分的阻力增大,油分提前堵塞。
Four. The excessive moisture on the oil filter material will cause the expansion of the filter material and the shrinkage of the micropores, so that the effective separation area of the oil can be reduced, the resistance of the oil is increased and the oil separation is blocked in advance.
济南空压机
五、当机组停机后外部的气流会随着小压力阀的泄漏处回流到油分,由于温度和气压的同时降低会使气体凝结成水滴,水滴进入油分就会使滤材吸水发胀变质。
Five, when the unit is shut down, the air flow will return to the oil point with the leakage of the minimum pressure valve. As the temperature and air pressure decrease at the same time, the gas will be condensed into water droplets, and the water drops into the oil will make the filter swollen and deteriorate.
因此,为了延长生产企业的空压机使用寿命,空压机在进行运作的时候,一定要注意以下七大注意事项:
Therefore, in order to extend the service life of air compressors in production enterprises, we must pay attention to the following seven points when operating the air compressors:
1、需要为空压机正常作业营造一个稳定的运行环境,那么就需要保持机站内卫生清洁、空气干燥、通风效果良好,比如:储气罐等需要放在通风良好避免在高温环境的直接烘烤与阳光直接照射引起暴晒。
1, it is necessary to create a stable and efficient operation environment for the high efficiency and normal operation of the air compressor, so it is necessary to keep clean, dry air and good ventilation in the station. For example, the storage tank and so on need to be put in a good ventilation to avoid direct roasting and direct sunlight exposure in the high temperature environment.
2、其压力不允许超越规定范围值。
2, its maximum pressure is not allowed to exceed the maximum range.
3、确保阀是灵敏有效的。
3, ensure that the safety valve is sensitive and effective.
4、针对储气罐、输气管道必须每隔两年时间为一个周期对其进行测试是否正常需要更换等。
4, for gas storage tanks, gas pipelines must be tested every two years for a period of normal replacement.
5、当我们启动机器的时候一定是在其没有负荷下开始运载,等到一切正常后才开始逐渐进到载荷运转。
5, when we start the machine, we must start loading without any load, and wait until everything is normal before we start to load gradually.
6、禁止在空压机出气口面前站人,当需要开启送气阀之前,应该将相应的输气管道都完好保持其通畅。
6. It is forbidden to stand in front of the outlet of the air compressor. When the valve is needed to be opened, the corresponding gas transmission pipeline should be kept intact.
7、当出现漏电、漏气、漏油、漏水、各参数值超过规定范围值时等等这些情况时应该马上停止空气压缩机进行检查,查找分析故障把故障排除后方可恢复正常的运行。
7, when the leakage, gas leakage, oil leakage, leakage, the value of all the parameters exceed the specified range and so on, we should immediately stop the air compressor to check, find out the fault to remove the fault and restore the normal operation.

电话:0531-85963300      手机:17553037111   18765879198    地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁ICP备18021911号-1

济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com     

鲁公网安备 37010502001004号