济南科邦机械设备有限公司您身边的济南空压机厂家!
18765879198

首页>企业新闻
螺杆式空气压缩机夏季高温应做高温处理
Time:2019-08-13 09:41:37       来源:http://www.jnkbjx.com/      

  螺杆式空气压缩机附件正常工作温度在75℃-95℃之间,当温度超过极限时,属于高温。高温有很多原因。分析和判断空压机高温产生的原因是解决空压机高温问题的前提和基础。在夏季高温下运行的设备,在夏季可能会遇到以下问题:

  The normal working temperature of screw air compressor accessories is between 75 and 95 C. When the temperature exceeds the limit, it belongs to high temperature. There are many reasons for the high temperature. Analyzing and judging the cause of high temperature of air compressor is the premise and foundation to solve the problem of high temperature of air compressor. Equipment operating at high temperature in summer may encounter the following problems in summer:
  1. 润滑油不足
  1. Insufficient lubricating oil
  不仅螺杆空气压缩机润滑油润滑,密封,它是主要的也是能够冷却装置,因此也称为“冷却液”,当机器缺少冷却液,压缩机产生的热量不能被冷却,温度会上升更高,这也是一个主要因素造成高温螺杆空气压缩机。
  Not only the lubricating oil of screw air compressor is lubricated and sealed, it is also the main cooling device, so it is also known as "coolant". When the machine lacks coolant, the heat generated by the compressor can not be cooled, and the temperature will rise higher, which is also a major factor causing high temperature screw air compressor.
  解决方案:加空压机油,如果是高温引起润滑油变质,则更换。
  Solution: add air compressor oil, if high temperature causes lubricant deterioration, then replace.
济南空压机
  二、温控阀失灵
  2. Failure of temperature control valve
  温控阀的作用是控制注油螺杆空压机主机的注油温度。它利用温度控制元件根据油温控制元件阀芯的开度,从而控制油量通过油冷却器,让冷、热油混合到主机上,从而控制喷油和排气温度!
  The function of the temperature control valve is to control the injection temperature of the main engine of the oil injection screw air compressor. It uses temperature control elements to control the opening of the valve core according to the oil temperature, so as to control the amount of oil through the oil cooler, so that the cold and hot oil can be mixed into the main engine, thus controlling the temperature of injection and exhaust.
  解决方案:更换温控阀芯。
  Solution: Replace the temperature control valve core.
  冷却器堵塞了
  The cooler is blocked.
  冷却器也俗称“散热器翅片”,螺杆式空压机内部循环的润滑油经冷却器冷却后再流回压缩机主机,当冷却器太脏而堵塞时,空压机润滑油无法冷却,因此回收会导致高温。
  Cooler is also commonly known as "radiator fin". The lubricant circulated in screw air compressor is cooled by the cooler and then returned to the compressor main engine. When the cooler is too dirty and blocked, the lubricant of air compressor can not be cooled, so the recovery will lead to high temperature.
  解决方法:用干燥的压缩空气清洗冷却器。如果冷却器不能清洗,将其取出并清洗。
  Solution: Clean the cooler with dry compressed air. If the cooler cannot be cleaned, remove it and clean it.
  4. 滤油器堵塞
  4. Blockage of oil filter
  机油滤清器的作用是过滤润滑油中的杂质,保护螺杆空压机的主机。如果长时间不更换,或者工作环境不好,机油滤清器会堵塞,压缩机内的油流量小,主机不能及时得到足够的润滑油冷却,会出现高温现象。
  The function of oil filter is to filter impurities in lubricating oil and protect the main engine of screw air compressor. If it is not replaced for a long time, or the working environment is not good, the oil filter will be blocked, the oil flow in the compressor is small, and the main engine can not get enough lubricating oil to cool in time, and high temperature will occur.
  解决方案:更换机油滤清器,或做一次全面的机油保养。
  Solution: Change the oil filter, or do a comprehensive oil maintenance.
  五、螺杆空压机主控制器故障
  5. Failure of Main Controller of Screw Air Compressor
  有一个随机的警报。如果这是空压机面板显示高温的原因。
  There is a random alarm. If this is the reason why the air compressor panel shows high temperature.
  解决方案:更换主控制器。
  Solution: Replace the main controller.
  温度传感器故障
  Temperature sensor failure
  空压机面板显示温度变化不稳定,或上升速度增加几摄氏度或十摄氏度以上,表示温度传感器故障。
  Air compressor panel shows unstable temperature change, or rising speed increases by several degrees Celsius or more, indicating temperature sensor failure.
  解决方案:更换温度传感器。
  Solution: Replace the temperature sensor.
  以上是济南空压机小编为大家整理的相关内容,想要了解更多内容,欢迎访问网站:http://www.jnkbjx.com
  The above is the relevant content of Jinan Air Compressor. For more information, please visit the website: http://www.jnkbjx.com.

电话:0531-85963300     手机:18765879198   地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁公网安备 37010502001004号 >

版权所有:济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com    技术支持:诺商信息

鲁公网安备 37010502001004号