济南科邦机械设备有限公司您身边的济南空压机厂家!
17553037111   18765879198

首页>企业新闻
购买空压机一定要注意的事项
Time:2019-06-21 15:44:15       来源:http://www.jnkbjx.com/      

  1.采购时只思索到价钱廉价,运用时发现质量太差,运转不稳定,毛病停机时间长,从而形成消费线停机损失,话说一分价钱份货,假如价钱廉价定在其他方面有所短板。

  1. When purchasing, we only think about the low price. When using it, we find that the quality is too poor, the operation is unstable, and the downtime of the faults is long, thus causing the loss of the downtime of the consumption line. If the price is low, we will have some shortcomings in other areas.
  2.采购时只思索运转稳定性,无视了能耗比值,日积月累形成宏大糜费,设备置办本钱约占5-10%,维护颐养本钱约占5-10%,电力耗费本钱约占80-90%。因而选购时要思索机器的工作效率,俭省便意味着赚钱。
  2. When purchasing, we only consider the stability of operation, ignore the ratio of energy consumption, and accumulate huge waste over time. The cost of equipment purchase accounts for about 5-10%, the cost of maintenance accounts for about 5-10%, and the cost of electricity consumption accounts for about 80-90%. Therefore, when choosing and purchasing, we should first consider the efficiency of the machine, and frugality means making money.
  3 运转稳定性和颐养便当性亦是同样需思索的要素。供给商的售后效劳质量,毛病检修无法及时到场,零配件采购不便等,均形成不用要损失。需留意调查供给商的售后效劳质量。
  3. Operational stability and convenience are also the key factors to be considered. Supplier's after-sales service quality, defect overhaul and inconvenience in purchasing spare parts all result in unnecessary loss. Attention should be paid to the quality of after-sales service provided by suppliers.
  济南空压机
  Jinan air compressor
  a.压缩机的大小,台数均需认真计算肯定。
  A. The size and number of compressors should be calculated carefully.
  b.后处置设备不是越多越好,而是视需求装备。
  B. Post-disposal equipment is not as much as possible, but as required.
  c.机房应尽量选在环境清洁,通风良好的。
  C. The machine room should be as clean and well ventilated as possible.
济南空压机
  d.管线布置尽量减少弯头,接头、管径选择亦应合理。
  D. Pipeline layout should minimize elbows, and the selection of joints and pipe diameters should also be reasonable.
  f.要思索用气场所和条件。如用气场地狭小(船用、车用),应选立式;如用气场所有长间隔的变化(超越500米),则应思索挪动式;假如运用场所不能供电,则应选择柴油机驱动式;假如运用场所没有自来水, 就必需选择风冷式。在风冷、水冷两种冷却方式上,用户常有错误的认识,以为水冷好,其实不然。国内外小型压缩机中,风冷式大约占到90%以上,这是由于在设计上风冷烦琐,运用时无需水源。而水冷式压缩机则合适大一些的场所,压缩机冷却效果有保证。
  F. Consider the place and condition of using gas. If the use of air space is narrow (marine, automotive), it should be vertical; if there is a long interval change in the use of air space (over 500 meters), it should consider moving type; if the use site can not supply electricity, it should choose diesel engine driving type; if there is no running water in the use site, it must choose air-cooled type. In air-cooled and water-cooled cooling modes, users often have a wrong idea that water-cooled is good, but in fact it is not. Air-cooled compressors account for more than 90% of small compressors at home and abroad. This is due to the tedious design of air-cooled compressors and the lack of water source when they are used. The water-cooled compressor is suitable for larger places, and the cooling effect of the compressor is guaranteed.
  济南空压机
  Jinan air compressor
  g.思索压缩空气质量。普通压缩机产生的压缩空气均含有一定量光滑油,并有一定量的水,有些场所是禁油和禁水的,这时不但对压缩机选型要留意,必要时要增加隶属安装。 处理的方法:一是选用无光滑压缩机。第二种也是常用的办法,是将压缩机(无论哪种)再加一级或二级净化安装或枯燥器。这种安装可使压缩机空气既不含油又不含水,使压缩空气中的含油水量在3ppm以下,可满足工艺请求。
  G. Consider the quality of compressed air. Compressed air produced by ordinary compressors contains a certain amount of smooth oil, and a certain amount of water. Some places are prohibited from oil and water. At this time, we should not only pay attention to the selection of compressors, but also increase subordinate installation when necessary. Processing methods: First, the use of non-smooth compressor. The second and commonly used method is to install or dry the compressor (either) with one or two levels of purification. This installation can make the compressor air neither oil nor water, so that the oil and water content in compressed air is less than 3 ppm, which can meet the process requirements.
  总之,倡议在规划选购和运用空压设备时,要综合思索设备效率,运转稳定性,颐养便利性和售后效劳质量;选择的设备供给商作整体规划。以上是济南空压机厂家为大家整理的相关内容,希望能帮助到大家,我们的网站是http://www.jnkbjx.com
  In a word, it is advocated that when planning the purchase and use of air compressor equipment, comprehensive consideration should be given to equipment efficiency, operation stability, accommodation convenience and after-sales service quality, and professional equipment suppliers should be selected for overall planning. Above is the related content that Jinan air compressor manufacturer arranges for everybody, hope to help everybody, our website is http://www.jnkbjx.com.

电话:0531-85963300      手机:17553037111   18765879198    地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁ICP备18021911号-1

济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com     

鲁公网安备 37010502001004号