济南科邦机械设备有限公司您身边的济南空压机厂家!
18765879198

首页>企业新闻
济南螺杆空压机压缩空气质量下降缘由和处理方法
Time:2019-06-10 10:56:32       来源:http://www.jnkbjx.com/      

  济南螺杆空压机压缩空气质量下降缘由和处理方法

  Causes and Treatment of Compressed Air Quality Decline of Jinan Screw Air Compressor
  螺杆空压机压缩空气质量下降现象:
  Decrease in compressed air quality of screw air compressor:
  螺杆空压机压缩空气质量下降主要是由于压缩空气中含油量增加灰尘等杂质所致。前者是最常见的现象之一。
  The decrease of compressed air quality of screw air compressor is mainly due to the increase of oil content in compressed air, dust and other impurities. The former is one of the most common phenomena.
  螺杆空压机易造成压缩空气质量下降的后果:
  The screw air compressor is easy to cause the consequence of the decrease of compressed air quality:
  众所周知,压缩机产品都是压缩空气,无论是作为动力还是作为空气的来源,压缩空气的质量是用户最关心的问题之一。因此,一旦压缩空气的质量下降,不仅会导致压缩空气的质量不达标而不能使用,对压缩设备造成损坏,而且由于空气中含油量高而导致严重爆炸。因此,长期以来,如何有效地提高空压机的压缩空气质量是一个重要的研究对象。
  As we all know, compressor products are compressed air. Whether as a power or as a source of air, the quality of compressed air is one of the most concerned problems for users. Therefore, once the quality of compressed air decreases, it will not only lead to the quality of compressed air not up to the standard and can not be used, but also cause damage to compressed equipment, and serious explosion due to the high oil content in the air. Therefore, for a long time, how to effectively improve the compressed air quality of air compressor is an important research object.
  如何提高螺杆空压机压缩空气的质量:
  How to improve the quality of compressed air in screw air compressor?
                                  济南螺杆空压机
  正因为有了以上的危害,所以人们一直希望空气压缩机的压缩空气质量越高越好。目前,为了提高压缩空气的质量,最常用的方法如下:
  Because of the above hazards, people always hope that the higher the compressed air quality of air compressor, the better. At present, in order to improve the quality of compressed air, the most commonly used methods are as follows:
  1. 装载空气过滤设备,达到改善压缩空气质量的目的。如螺杆空压机安装空气滤清器、油气分离器等。
  1. Loading air filter equipment to improve the quality of compressed air. For example, screw air compressor installs air filter, oil and gas separator, etc.
  2. 控制润滑油用量。由于过量的润滑油容易导致压缩空气中含油量的增加,所以有必要将润滑油的量控制在一个合理的范围内,不能过低,也不能过高。
  2. Control the amount of lubricating oil. Because excessive lubricating oil can easily lead to the increase of oil content in compressed air, it is necessary to control the amount of lubricating oil in a reasonable range, not too low, not too high.
  3.检查单向阀、油气分离器、最小压力阀弹簧等部件的节流孔是否堵塞或损坏。一旦发现这些部件不能正常工作,就必须对它们进行处理。
  3. Check whether throttle holes of unidirectional valves, oil and gas separators, minimum pressure valve springs and other components are blocked or damaged. Once these components are found to be not working properly, they must be treated.
  4. 检查排气压力。螺杆空压机排气压力过低,也会导致压缩空气的质量下降。因此,我们需要确保空压机的卸载压力设置在合适的范围内。
  4. Check the exhaust pressure. The low exhaust pressure of screw air compressor will also cause the quality of compressed air to decline. Therefore, we need to ensure that the unloading pressure of the air compressor is set within an appropriate range.

电话:0531-85963300     手机:18765879198   地址:济南市天桥区无影山中路130号重汽彩世界     备案号:鲁公网安备 37010502001004号 >

版权所有:济南科邦机械设备有限公司 济南科邦机械主营::济南空压机及配件 网址:http://www.jnkbjx.com    技术支持:诺商信息

鲁公网安备 37010502001004号